Renault Koleos Service Repair Manual: Rear screen: Removal - Refitting

REMOVAL

I - REMOVAL PREPARATION OPERATION

  • Remove:
    • the tailgate trim (see Tailgate trim: Removal - Refitting) (73A, Non-side opening elements trim),
    • the rear screen wiper arm (see Rear screen wiper arm: Removal - Refitting) (85A, Washing - Wiping),
    • the tailgate locking switch (see Tailgate locking switch: Removal - Refitting) (87C, Opening element management).
  • Disconnect the heated rear screen wiring connector and the aerial connector as well as the earths located against the rear screen.
  • Protect the edges of the rear screen using masking tape.

II - OPERATION FOR REMOVAL OF PART CONCERNED

Windows

  • Begin cutting the cement bead.

REFITTING

I - REFITTING PREPARATIONS OPERATION

  • For the preparation and the bonding (see Window bonding: Description) (Technical Note 560A, 54A, Windows).

II - REFITTING OPERATION FOR PART CONCERNED

Note: Use high modulus adhesive for bonding the rear screen.

Windows

  • Refit the rear screen mouldings (1) .
  • Use the correct size of cement bead.
  • Bond the rear screen (this operation requires two people).
  • Respect the following clearances and shut lines:
    • rear screen - roof,
    • rear screen - rear wings.

III - FINAL OPERATION.

Windows

  • Connect the heated rear screen wiring connector and the aerial connector as well as the earths located against the rear screen.
  • Refit:
    • the tailgate locking switch (see Tailgate locking switch: Removal - Refitting) (87C, Opening element management),
    • the rear screen wiper arm (see Rear screen wiper arm: Removal - Refitting) (85A, Washing - Wiping),
    • the tailgate trim (see Tailgate trim: Removal - Refitting) (73A, Non-side opening elements trim).
    Rear quarter panel window: Removal - Refitting

    Exterior protection

    See More:

    Renault Koleos Service Repair Manual > Driveshafts: Front left-hand driveshaft gaiter, gearbox side: Removal - Refitting
    Small clip Driveshaft gaiter Big clip Spider Driveshaft yoke sleeve Deflector Lock ring REMOVAL I - OPERATION FOR REMOVAL OF PART CONCERNED Position the vehicle on a two-post lift (see Vehicle: Towing and lifting) (02A, Lifting equipment). IMPORTANT To prevent the vehicle from falling, lash it to t ...

    Renault Koleos Owners Manual

    Renault Koleos Service Repair Manual

    © 2018-2021 Copyright www.rkoleos.com
    0.0114