Renault Koleos Service Repair Manual: Differential output seal: Removal - Refitting

Renault Koleos Service Repair Manual / Transmission / Rear axle / Differential output seal: Removal - Refitting

4X4 TRANSMISSION

Rear axle

IMPORTANT Consult the safety and cleanliness advice and operation recommendations before carrying out any repair.

REMOVAL

I - REMOVAL PREPARATION OPERATION

  • Position the vehicle on a two-post lift (see Vehicle: Towing and lifting) .
IMPORTANT To prevent the vehicle from falling, lash it to the vehicle lift using a strap.
  • Drain the oil from the rear final drive (see 26A, Rear axle, Rear axle oil: Draining - Filling, page 26A- 11) .
  • Remove:
    • the rear wheel on the side concerned (see Wheel: Removal - Refitting) (35A, Wheels and tyres).
    • the rear wheel driveshaft on the side concerned (see 29A, Driveshafts, Rear wheel driveshaft: Removal - Refitting, page 29A-8) .

II - OPERATION FOR REMOVAL OF PART CONCERNED

Rear axle

  • Remove the differential output seal (1) from the side concerned using a screwdriver, without scratching the mating surface.

REFITTING

I - REFITTING OPERATION FOR THE PART CONCERNED

Rear axle

  • Refit the differential output seal using the tool (Bvi. 1855) (2) .

II - FINAL OPERATION.

  • Refit:
    • the rear wheel driveshaft on the side concerned (see 29A, Driveshafts, Rear wheel driveshaft: Removal - Refitting, page 29A-8) ,
    • the rear wheel on the side concerned (see Wheel: Removal - Refitting) (35A, Wheels and tyres).
  • Fill the rear final drive with oil (see 26A, Rear axle, Rear axle oil: Draining - Filling, page 26A-11) .

Rear axle oil: Specifications

4X4 TRANSMISSION

I - FINAL DRIVE TYPE/OIL TYPE CORRELATIONS:

Rear axle

Note: DANA final drive: FE 80W90 oil is equivalent to 75W90 oil (100% compatible)

II - STANDARDS AND PART NUMBERS OF THE VARIOUS RECOMMENDED OILS:

Rear axle

    Longitudinal driveshaft input seal: Removal - Refitting

    Rear axle oil: Draining - Filling

    See More:

    Renault Koleos Service Repair Manual > Driveshafts: Front right-hand driveshaft gaiter, gearbox side: Removal - Refitting
    Small clip Driveshaft gaiter Big clip Spider Driveshaft yoke sleeve Relay shaft bearing Relay shaft bearing bracket Deflector Deflector REMOVAL I - OPERATION FOR REMOVAL OF PART CONCERNED Position the vehicle on a two-post lift (see Vehicle: Towing and lifting) (02A, Lifting equipment). IMPORTANT T ...

    Renault Koleos Owners Manual

    Renault Koleos Service Repair Manual

    © 2018-2021 Copyright www.rkoleos.com
    0.0123